Chevrolet Cavalier 1995-2005 fuse box and relay Diagrams
The Chevrolet Cavalier (1995-2005) depends on its fuse box and relays to regulate its electrical system. The fuse box is located under the dashboard on the driver’s side, managing critical functions such as the headlights, turn signals, radio, and wipers. Each fuse in the box is designed to protect specific circuits by cutting off power when an overload or short circuit occurs, preventing potential damage to the electrical system.
The Cavalier also utilizes relays to control high-power functions, including the cooling fan, starter motor, and fuel pump. These relays act as switches, allowing a small current to control larger electrical loads. If a relay malfunctions, it can disrupt vital operations, such as preventing the engine from starting or causing the cooling fan to stop working.
Regular inspection and replacement of fuses and relays in the Chevrolet Cavalier ensure that the vehicle’s electrical systems continue to function properly, avoiding common issues like blown fuses or faulty relays that could lead to system failures.
MUST READ: DYI – How to Check Car Fuses?
(1995-2005) Chevrolet Cavalier fuse box and relay with Diagram
WARNING
- Never replace a fuse with one that has a higher amperage rating.
- A fuse with a too-high amperage could damage the electrical part and cause a fire.
- On no account should fuses be repaired (e.g. patched up with tin foil or wire) as this may cause serious damage elsewhere in the electrical circuit or cause a fire.
- If a fuse blows repeatedly, do not keep replacing it. Instead, have the cause for the repeated short circuit or overload tracked and fixed.
- Terminal and harness assignments for individual connectors will vary depending on vehicle equipment level, model, and market.
Chevrolet Cavalier 1995-2005 fuse assignment
- Cigar lighter / power outlet fuses in the Chevrolet Cavalier are located in the Instrument panel fuse box (see fuses “CIG” (Cigarette Lighter) and “APO” (Accessory Power Outlet, if equipped)).
Year of production: from 1995, 1996, 1997, 1998, 1999, 2000, 2001, 2002, 2003, 2004, 2005
Fuse box location
Instrument Panel
The fuse box is located on the driver’s side of the instrument panel, behind the cover.
Engine Compartment
It is located in the engine compartment (left-side).
Fuse box diagrams
1995
Instrument Panel
Assignment of the fuses and relay in the Instrument Panel Fuse Box (1995)
| Fuse | Circuitry |
|---|---|
| AIR BG 1 | Air Bag-DERM (Diagnostic Energy Reserve Module) Power |
| AIR BG 2 | Air Bag-DERM Crank Signal |
| ALARM | Alarm Module: Illuminated Entry, Warning Chimes |
| CIG | Cigar Lighter, Horn, Diagnostic Connector |
| CLS/PCM | Instrument Cluster, Powertrain Control Module |
| CLUSTER | Instrument Cluster, Anti-Lock Brake System |
| CRUISE | Cruise Control |
| DRL | Daytime Running Lamps |
| ERLS | Automatic Transaxle, Brake-Transaxle Shift Interlock, A/C Compressor, Cruise Control, Exhaust Gas Recirculation (2.2L Engine), Cannister Purge Valve, A/C High Pressure Switch (2.3L Engine) |
| EXT LAMP | Park Lamps, Side Marker Lamps, Instrument Panel Lamp |
| F/P-INJ | Fuel Pump, Fuel Injectors |
| FLSH-PAS | Flash To Pass Lamps |
| HEADLAMP | Headlamps |
| HVAC | Heater/A/C Control, Rear Window Defogger, Anti-lock Brake System, Engine Cooling Fan (2.2L Engine), Engine Vent Heater (2.3L Engine) |
| IGN | Engine Ignition |
| INST LPS | Instrument Panel Lamps |
| INT LAMP | Alarm Module: illuminated Entry, Warning Chimes, Overhead Lamps, Map/Reading Lamps, Glove Box Lamp, Trunk Lamp, Radio, Power Mirrors |
| O2 HTR | Rear O2 HTR Sensor Heater (2.3L Engine, Cal. Auto) |
| PCM/IGN | Powertrain Control Module |
| PWR ACC | Power Door Lock |
| PWR WINDOW | Power Windows, Power Sunroof |
| RADIO | Radio |
| RR DFOG | Rear Window Defogger |
| STOP-HAZ | Stop Lamps, Hazard Lamps |
| TURN-B/U | Turn Signal Lamps, Backup Lamps |
| WIPER | Windshield Wipers, Windshield Washers |
Engine Compartment
Assignment of the fuses and relay in the Engine Compartment Fuse Box (1995)
| Fuse | Circuitry |
|---|---|
| A/C | A/C Compressor (2.3L Engine) |
| ABS | Anti-Lock Brake System |
| ABS | Electronic Variable Orifice Steering, Anti-Lock Brake System |
| BATT 1 | Power ACC/Stop Lamp Circuits |
| BATT 2 | Lighting Circuits |
| BLO | Heater/ A/C Blower |
| COOLING FAN | Engine Cooling Fan |
| GEN | Generator-Voltage Sense |
| IGN | Ignition Switch Circuits |
| PCM | Powertrain Control Module |
1996, 1997
Instrument Panel
Assignment of the fuses and relay in the Instrument Panel Fuse Box (1996, 1997)
| Fuse | Circuitry |
|---|---|
| TURN-B/U | Exterior Lamps, Back-up Lamps |
| F/P-INJ | Fuel Pump, Fuel Injectors |
| CLUSTER | Instrument Cluster, Anti-Lock Brake System |
| CLS/PCM | Instrument Cluster, Powertrain Control Module, Daytime Running Lamps |
| RR DFOG | Rear Window Defogger |
| O2 HTR | Multiport Fuel Injection |
| WIPER | Windshield Wipers, Windshield Washers |
| ERLS | Automatic Transaxle, Brake-Transaxle Shift Interlock, A/C Compressor, Cruise Control, Multiport Fuel Injection |
| AIR BAG | Supplemental Inflatable Restraint System |
| EXT LAMP | Exterior Lamps, Instrument Panel Lights |
| PWR ACC | Power Door Locks, Convertible Top (Convertible Model) |
| HVAC | Heater and A/C Control, Anti-Lock Brake System, Engine Cooling Fan (2.2L Engine), Engine Vent Heater (2.4L Engine) |
| RADIO | Radio, Remote Keyless Entry |
| ALARM | Alarm Module – Interior Lamps, Warning Chime |
| CRUISE | Cruise Control |
| L HDLP | Left Headlamp |
| CIG | Cigarette Lighter, Horn, Interior Lamps, Diagnostic Connector |
| INST LPS | Instrument Panel Lights, Warning Chimes |
| STOP/HAZ | Exterior Lamps, Anti-Lock Brake System, Cruise Contro |
| PWR WINDOW | Power Windows, Power Sunroof, Convertible Top Controls (Convertible Model) (Circuit Breaker) |
| PCM/IGN | Powertrain Control Module |
| INT LAMP | Alarm Module: Illuminated Entry, Warning Chimes, Overhead Lamps, Mapmeading Lamps, Glove Box Lamp, Trunk Lamp, Radio, Power Mirrors, Remote Keyless Entry |
| FOG LAMP | Fog Lamps (2-24 Only) |
| IGN | Engine Ignition |
| R HDLP | Right Headlamp |
Engine Compartment
Assignment of the fuses and relay in the Engine Compartment Fuse Box (1996, 1997)
| Fuse | Circuitry |
|---|---|
| IGN | Ignition Switch Circuits |
| BATT 1 | Power ACC/Stoplamp Circuits |
| BATT 2 | Lighting Circuits |
| ABS | Electronic Variable Orifice Steering, Anti-Lock Brake System |
| COOLING FAN | Engine Cooling Fan |
| BLO | Heater and A/C Blower |
| PCM | Powertrain Control Module |
| A/C | A/C Compressor |
| ABS/EVO | Anti-Lock Brake System |
| GEN | Gen Voltage Sensor (2.2L Engine) |
1998
Instrument Panel
Assignment of the fuses and relay in the Instrument Panel Fuse Box (1998)
| Fuse | Circuitry |
|---|---|
| TRN-BL | Exterior Lamps, Back-up Lamps |
| F/P-INJ | Fuel Pump, Fuel Injectors |
| RR DFOG | Rear Window Defogger |
| CLUSTER | Instrument Cluster, Anti-Lock Brake System |
| CLS/PCM | Instrument Cluster, Powertrain Control Module, Daytime Running Lamps |
| O2 HTR | Multiport Fuel Injection |
| WIPER | Windshield Wipers, Windshield Washers |
| ERLS | Automatic Transaxle, Brake-Transaxle Shift Interlock, A/C Compressor, Cruise Control, Multiport Fuel Injection |
| AIR BAG | Supplemental Inflatable Restraint System |
| PWR ACC | Power Door Locks, Convertible Top (Convertible Model Only) |
| EXT LAMP | Exterior Lamps, Instrument Panel Lights |
| HVAC | Heater and A/C Control, Anti-lock Brake System, Engine Cooling Fan |
| RADIO | Radio, Remote Keyless Entry |
| ALARM | Alarm Module – Interior Lamps, Warning Chime |
| CRUISE | Cruise Control |
| STOP/HAZ | Exterior Lamps, Anti-Lock Brake System, Cruise Control, Turn Signals |
| CIG | Cigarette Lighter, Horn, Interior Lamps, Diagnostic Connector |
| INST LPS | Instrument Panel Lights, Warning Chimes |
| PCM/IGN | Powertrain Control Module |
| L HDLP | Left Headlamp, Fog Lamp (2-24) |
| INT LAMP | Alarm Module: Illuminated Entry, Warning Chimes, Overhead Lamps, MapReading Lamps, Glove Box Lamp, Trunk Lamp, Radio, Power Mirrors, Remote Keyless Entry |
| IGN | Engine Ignition |
| R HDLP | Right Headlamp, Fog Lamp (2-24) |
| PWR WDO/SRF | Power Windows, Power Sunroof, Convertible Top Controls (Convertible Models) (Circuit Breaker) |
| DRL | Daylight Running Lamps (Relay) |
Engine Compartment
Assignment of the fuses and relay in the Engine Compartment Fuse Box (1998)
| Fuse | Circuitry |
|---|---|
| IGN | Ignition Switch Circuits |
| BATT 1 | Power ACC/Stoplamp Circuits |
| BATT 2 | Lighting Circuits |
| ABS | Anti-Lock Brake System |
| COOLING FAN | Engine Cooling Fan |
| TACH | Tachometer |
| BLO | Heater and A/C Blower |
| PCM | Powertrain Control Module |
| A/C | A/C Compressor |
| ABS/EVO | Anti-Lock Brake System |
| GEN | Gen Voltage Sensor (2.2L Engine) |
1999
Instrument Panel
Assignment of the fuses and relay in the Instrument Panel Fuse Box (1999)
| Fuse | Circuitry |
|---|---|
| TRN-BL | Exterior Lamps, Back-up Lamps |
| F/P-INJ | Fuel Pump, Fuel Injectors |
| RR DFOG | Rear Window Defogger |
| CLUSTER | Instrument Cluster, Anti-Lock Brake System |
| CLS/PCM | Instrument Cluster, Powertrain Control Module, Daytime Running Lamps |
| O2 HTR | Rear O2 Sensor Heater |
| WIPER | Windshield Wipers, Windshield Washers |
| ERLS | Automatic Transaxle, Brake Transaxle Shift Interlock (BTSI), A/C Compressor, Cruise Control, Multiport Fuel Injection |
| AIR BAG | Supplemental Inflatable Restraint (SIR) System |
| PWR ACC | Power Door Locks, Convertible Top (Convertible Model Only) |
| EXT LAMP | Exterior Lamps, Instrument Panel Lights |
| HVAC | Heater and A/C Control, Anti-lock Brake System, Engine Cooling Fan |
| RADIO | Radio, Remote Keyless Entry |
| ALARM | Alarm Module – Interior Lamps, Warning Chime |
| CRUISE | Cruise Control |
| STOP/HAZ | Exterior Lamps, Anti-Lock Brake System, Cruise Control, Turn Signals |
| CIG | Cigarette Lighter |
| INST LPS | Instrument Panel Lights, Warning Chimes |
| PCM/IGN | Powertrain Control Module |
| L HDLP | Left Headlamp, Fog Lamp (Z-24 Model Only) |
| INT LAMP | Alarm Module: Illuminated Entry, Warning Chimes, Overhead Lamps, Map/Reading Lamps, Glove Box Lamp, Trunk Lamp, Radio, Power Mirrors, Remote Keyless Entry |
| IGN | Engine Ignition |
| R HDLP | Right Headlamp, Fog Lamp (Z-24 Model Only) |
| HORN | Horn, Diagnostic Connector |
| PWR WDO/SRF | Power Windows, Power Sunroof, Convertible Top Controls (Convertible Model Only) (Circuit Breaker) |
| DRL | Daylight Running Lamps (Relay) |
Engine Compartment
Assignment of the fuses and relay in the Engine Compartment Fuse Box (1999)
| Fuse | Circuitry |
|---|---|
| IGN | Ignition Switch Circuits |
| BATT 1 | Power ACC/Stoplamp Circuits |
| BATT 2 | Lighting Circuits |
| ABS | Anti-Lock Brake System |
| COOLING FAN | Engine Cooling Fan |
| BLO | Heater and A/C Blower |
| PCM | Powertrain Control Module |
| A/C | A/C Compressor |
| ABS/EVO | Anti-Lock Brake System |
2000, 2001
Instrument Panel
Assignment of the fuses and relay in the Instrument Panel Fuse Box (2000, 2001)
| Fuse | Circuitry |
|---|---|
| TURN-B/U | Turn Signals, Back-Up Lamps |
| ERLS | Engine Relays |
| BCM/CLU | Body Control Module, Instrument Panel Cluster |
| PCM | Powertrain Control Module |
| IGN MDL | Ignition Module |
| F/P-INJ | Fuel Pump, Fuel Injectors |
| AIR BG | Air Bag |
| CRUISE | Cruise Control Switch |
| ABS | Anti-Lock Brake (Ignition) |
| Blank | Not Used |
| RFA BATT | Remote Keyless Entry System |
| MIRROR | Power Mirror |
| LT HDLP | Left Headlamp |
| RDO/INTLP | Radio, Interior Lamps |
| RT HDLP | Right Headlamp |
| CLSTR | Instrument Panel Cluster |
| EXT LP | Exterior Lamps |
| CIG | Cigarette Lighter, Diagnostic Link Connector |
| FOG | Fog Lamps |
| HORN | Horn |
| Blank | Not Used |
| Blank | Not Used |
| STOP/HZD | Stop Lamps, Hazard Lamps |
| Blank | Not Used |
| Blank | Not Used |
| RR DEFOG | Rear Window Defogger |
| PWR ACC | Power Door Locks, Convertible Top Switch |
| Blank | Not Used |
| Blank | Not Used |
| Blank | Not Used |
| O2 HTR | Oxygen Sensor Heater |
| HVAC | Climate Control System |
| WIPER | Windshield Wiper |
| BCM | Body Control Module |
| Blank | Not Used |
| PWR WDO | Power Windows, Sunroof, Convertible Top (Circuit Breaker) |
| DRL | Daytime Running Lamps (Relay) |
Engine Compartment
Assignment of the fuses and relay in the Engine Compartment Fuse Box (2000, 2001)
| Fuse | Circuitry |
|---|---|
| IGN | Ignition Switch Circuits |
| BATT 1 | Power ACC/Stoplamp Circuits |
| BATT 2 | Lighting Circuits |
| ABS | Anti-Lock Brake System |
| COOLING FAN | Engine Cooling Fan |
| PCM/HVAC | Powertrain Control Module, Heater and A/C Blower |
| BLO | Heater and A/C Blower |
| PCM | Powertrain Control Module |
| A/C | A/C Compressor |
| FUEL PUMP | Fuel Pump |
| HEATER BLOWER | Heater and A/C Blower |
2002, 2003, 2004, 2005
Instrument Panel
Assignment of the fuses and relay in the Instrument Panel Fuse Box (2002-2005)
| Fuse | Circuitry |
|---|---|
| TURN-B/U | Turn Signals, Back-Up Lamps |
| ERLS | Engine Relays |
| BCM/CLU | Body Control Module, Instrument Panel Cluster |
| PCM | Powertrain Control Module |
| IGN MDL | Ignition Module |
| F/P-INJ | Fuel Pump, Fuel Injectors |
| AIR BG | Air Bag |
| CRUISE | Cruise Control Module/Switch |
| ABS | Anti-Lock Brake (Ignition) |
| APO | Accessory Power Outlet |
| RFA BATT | Remote Keyless Entry System |
| MIR/DLC | Power Mirror/Diagnostic Link Connector |
| LT HDLP | Left Headlamp |
| RDO/INTLP | Radio, Interior Lamps |
| RT HDLP | Right Headlamp |
| CLSTR | Instrument Panel Cluster |
| EXT LP | Exterior Lamps |
| CIG | Cigarette Lighter |
| FOG | Fog Lamps |
| HORN | Horn |
| Blank | Not Used |
| Blank | Not Used |
| STOP/HZD | Stop Lamps, Hazard Lamps |
| Blank | Not Used |
| Blank | Not Used |
| RR DEFOG | Rear Window Defogger |
| PWR ACC | Power Door Locks |
| Blank | Not Used |
| Blank | Not Used |
| Blank | Not Used |
| O2 HTR | Oxygen Sensor Heater |
| HVAC | Climate Control System |
| WIPER | Windshield Wiper |
| BCM | Body Control Module |
| AMPL | Audio Amplifier |
| PWR WDO | Power Windows, Sunroof |
| RELAY DRL | Daytime Running Lamps (Relay) |
| Blank | Not Used |
Engine Compartment
Assignment of the fuses and relay in the Engine Compartment Fuse Box (2002-2005)
| Fuse | Circuitry |
|---|---|
| IGN | Ignition Switch Circuits |
| BATT 1 | Exterior Lamps, Power Outlet, Horn, Audio Amplifier |
| BATT 2 | Rear Defogger, Starter, Power Locks, Stoplamps |
| ABS | Anti-Lock Brake System |
| COOLING FAN | Engine Cooling Fan |
| PCM/HVAC | Powertrain Control Module, Heater and A/C Blower |
| CRNK | Starter |
| BLO | Heater and A/C Blower |
| PCM | Powertrain Control Module |
| A/C | A/C Compressor |
| A/C | A/C Compressor |
| FUEL PUMP | Fuel Pump |
| CRNK | Starter |
| COOLING FAN | Engine Cooling Fan |
| HEATER BLOWER | Heater and A/C Blower |
Conclusion
For owners and enthusiasts of classic Chevrolet Cavalier 1995-2005, understanding the fuse box and relay systems is essential for vehicle maintenance. Regular inspection and maintenance of these components helped ensure the vehicle’s longevity and reliability, preserving its status as a symbol of Chevrolet’s craftsmanship and innovation in the automotive industry during that era.